1Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15Models:QFI30-CQFI35-COwner’s ManualInstallation and OperationDO NOT DISCARD THIS MANUAL
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1510J. Lighting Instructions (IPI) FOR YOUR SAFETY READ BEFORE LIGHTINGTO TURN OFF GAS TO
11Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15Initial Break-in Procedure• The appliance should be run three to four hours continuous
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1512Glass CleaningFrequency: SeasonallyBy: HomeownerTools Needed: Protective gloves, glass
13Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15VentingFrequency: SeasonallyBy: HomeownerTools needed: Protective gloves and safety
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1514Burner Ignition and OperationFrequency: AnnuallyBy: Service TechnicianTools needed: Pr
15Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15A. Typical Appliance SystemNOTICE: Illustrations and photos refl ect typical installat
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1516B. Design and Installation ConsiderationsQuadra-Fire gas inserts are designed for inst
17Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/155 5 Fireplace Size Requirements A. Minimum Fireplace OpeningMinimum fi replace openi
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1518Figure 5.2 Fireplace OpeningIn addition to these dimensions, also reference Clearances
19Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15B. Mantel and Wall ProjectionsWARNING! Risk of Fire! Comply with all minimum clear-an
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/152Listing Label Information/LocationModel Name: __________________________________________
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1520A. Vent Termination Minimum ClearancesRoof Pitch H (Min.) Ft.Flat to 6/12...
21Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/157 7 Installation Preparation Prepare the existing solid fuel masonry or factory buil
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1522B. Venting ComponentsCAUTION! Risk of Cuts/Abrasions/Flying Debris. Wear protective glo
23Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15Figure 8.2 CUT AND BEND FLASHING AS NEEDEDTO FIT CHIMNEYSEALANTADHESIVE• Trim chimn
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1524E. Remote ControlIPI Models:If a remote control kit is used to control blower function,
25Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15F. Installing Adaptor and Termination CapFor installation of termination cap see mini
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1526A. Fuel Conversion• Make sure the appliance is compatible with available gas types.•
27Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15A. Wiring RequirementsNOTICE: This appliance must be electrically wired and grounded
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1528Figure 10.2 Fan Wiring DiagramBLOWERSBLOWER RECEPTACLEBLKGRNBLKBLKGRNBLKWHTGRNBLKBLKGR
29Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15PLUG 120V EXISTINGOUTLETGRN (2)BLK (2)BLK (2)GRN (2)BLK (2)STEPS3 & 4WHT (2)BLOWER
3Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15 Safety Alert Key:• DANGER! Indicates a hazardous situation which, if not avoided wi
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/153011 11 Finishing A. Mantel and Wall ProjectionsWARNING! Risk of Fire! Comply with all
31Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15A. Remove Glass AssemblySee Section 12.H.B. Remove the Shipping MaterialsRemove shipp
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1532G. Install the Log AssemblyFigure 4. Install Side RefractoryFigure 5. Bend Refractor
33Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15Log #2 (SRV2227-702): Rest left end of log on the fl at spot of Log 1. See Figure 6 an
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15342227-935BLog #4 (SRV2227-705): Mate the slot on the bottom of the log, shown in Figure
35Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15G. Install the Log AssemblyLog Set Assembly: LOGS-QFI35Models: QFI35, QFI35-CInstal
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1536Log #2 (SRV2225-703): Mate the grate tine with the slot on the bottom of Log #2. The
37Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/152225-935CLog #5 (SRV2225-710): Position Log #5 as shown in Figure 12. Mate the middl
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1538I. Air Shutter SettingAir shutter settings should be adjusted by a qualifi ed ser-vice
39Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1513 13 Troubleshooting With proper installation, operation, and maintenance your gas a
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/154B. Limited Lifetime WarrantyX Molded refractory panels4021-645G 2/15 Page 1 of 2Hear
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1540Symptom Possible Cause Corrective Action4. Pilot lights but con-tinues to spark, and ma
41Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1514 14 Reference Materials A. Appliance/Decorative Front Dimension DiagramsDimension
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1542AF-QFI30, AF-QFI35 DECORATIVE FRONTSFigure 14.2 Decorative Front Dimensions FSP-Q
43Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15Figure 14.3 Decorative Front Dimensions TP-QFI30/TP-QFI35 DECORATIVE FRONTSGABCD
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1544Figure 14.4 Direct Vent Flex Liner KitsFigure 14.5 Direct Vent Flex Liner Accessory K
45Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15Service PartsRBeginning Manufacturing Date: Aug 2011 Ending Manufacturing Date: Active
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1546Service PartsRBeginning Manufacturing Date: Aug 2011 Ending Manufacturing Date: ActiveQ
47Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15Service PartsRBeginning Manufacturing Date: Aug 2011 Ending Manufacturing Date: Active
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/1548Service PartsRBeginning Manufacturing Date: Aug 2011 Ending Manufacturing Date: ActiveI
49Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15Quadra-Fire, a brand of Hearth & Home Technologies7571 215th Street West, Lakevill
5Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15B. Limited Lifetime Warranty (continued)WARRANTY CONDITIONS:• This warranty only cove
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/156C. BTU Specifi cationsMODELS: QFI30-C, QFI35-CLABORATORY: Underwriters Laboratories, In
7Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/152 2 Operating Instructions Figure 2.1 General Operating PartsB. Your FireplaceWARNIN
Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/158C. Clear SpaceWARNING! DO NOT place combustible objects in front of the fi replace or blo
9Quadra-Fire • QFI30-C, QFI35-C • 2227-901 Rev. Q • 3/15Figure 2.3 Control ModuleI. Before Lighting FireplaceBefore operating this fi replace
Commentaires sur ces manuels