Rwww.quadrafire.com250-6422DOctober 11, 2005CASTILE PELLET STOVEO-T LTested and Listed byBeavertonOregon USAOMNI-Test Laboratories, Inc.COwner’s Manual
Page 10250-6422DOctober 11, 2005RCastile Pellet Stove RRDo not terminate vent in any enclosed or semi-enclosed area such as a carport, garage, attic,
RRROctober 11,, 2005250-6422DPage 11Castile Pellet Stove Improper installation, adjustment, alteration, service or maintenance can cause injury or pr
Page 12250-6422DOctober 11, 2005RCastile Pellet Stove RR5Venting SystemsNOTE:• Illustrations reflect typical installations and are FOR DESIGN PURPOSE
RRROctober 11,, 2005250-6422DPage 13Castile Pellet Stove 12 in.(305mm)MinimumNoncombustible Hearth PadWallThimbleHorizontalTerminationCap2 in.(51mm)M
Page 14250-6422DOctober 11, 2005RCastile Pellet Stove RRWe recommend a minimum of 60 in. (1524mm) vertical, however above the eave is preferred
RRROctober 11,, 2005250-6422DPage 15Castile Pellet Stove Fire HazardInspection of Chimney:• Masonry chimney must be in good condition.• Meets minim
Page 16250-6422DOctober 11, 2005RCastile Pellet Stove RR6Mobile Home1. An outside air inlet must be provided for the combustion air and must remain
RRROctober 11,, 2005250-6422DPage 17Castile Pellet Stove 7Appliance Set-UpA. Outside Air Kit Instructions Flex HoseHose ClampCollar AssemblyTrim Ring
Page 18250-6422DOctober 11, 2005RCastile Pellet Stove RR3 to 3 inch Top Vent Adapter 3 to 6 inch Top Vent Offset Adapter 1. Put a layer of high te
RRROctober 11,, 2005250-6422DPage 19Castile Pellet Stove E. Optional Log Set Placement Instructions4 PIECE LOG SET INSTALLATIONFigure 19.1CAUTIONLog
Page 2250-6422DOctober 11, 2005RCastile Pellet Stove RRand Welcome to the Quadra-Fire Family!Hearth & Home Technologies welcomes you to our tradi
Page 20250-6422DOctober 11, 2005RCastile Pellet Stove RR1. A 12 volt AC thermostat is required to operate this pellet appliance. You may use the in
RRROctober 11,, 2005250-6422DPage 21Castile Pellet Stove 8Operating InstructionsA. Fuel Size And Material1. Wood PelletsFuel pellets are made from s
Page 22250-6422DOctober 11, 2005RCastile Pellet Stove RRFigure 22.1Figure 22.2C. Before Your First Fire1. First, make sure your appliance has
RRROctober 11,, 2005250-6422DPage 23Castile Pellet Stove G Iginition Cycles1. During each ignition cycle, it is normal to see some smoke i
Page 24250-6422DOctober 11, 2005RCastile Pellet Stove RR9TroubleshootingWith proper installation, operation, and maintenance your appliance will prov
RRROctober 11,, 2005250-6422DPage 25Castile Pellet Stove Symptom Possible Cause Corrective ActionSlow or smoky start-up (Cont’d)Dirty exhaust and/or
Page 26250-6422DOctober 11, 2005RCastile Pellet Stove RRSymptoms Possible Cause Corrective ActionConvection blower fails to start.#1 snap disc defect
RRROctober 11,, 2005250-6422DPage 27Castile Pellet Stove 10Maintaining & Servicing Your ApplianceFigure 27.1 - Large Clinker3. Cleaning Ash Pan•
Page 28250-6422DOctober 11, 2005RCastile Pellet Stove RR6. Disposal of Ashes• Frequency: As needed• By: Homeowner• Task:Ashes should be plac
RRROctober 11,, 2005250-6422DPage 29Castile Pellet Stove 10. Cleaning the Exhaust Path• Frequency: As needed• By: Homeowner• Task: a. Applian
RRROctober 11,, 2005250-6422DPage 3Castile Pellet Stove Section 1: Listing and Code Approvals A. Appliance Certifications ...4 B
Page 30250-6422DOctober 11, 2005RCastile Pellet Stove RRCorrect Flame Size, Yellow/White in ColorCorrectFigure 30.3Tall, Lazy Flame, Orange in ColorI
RRROctober 11,, 2005250-6422DPage 31Castile Pellet Stove 1. Convection Blower Replacementa. Turn down thermostat, let appliance completely cool and
Page 32250-6422DOctober 11, 2005RCastile Pellet Stove RRE. Igniter ReplacementF. Baffle Removal a. Turn down thermostat, let the appliance c
RRROctober 11,, 2005250-6422DPage 33Castile Pellet Stove G. Glass Replacement• Glass is 5mm thick high temperature heat-resistant ceramic glass.•
Page 34250-6422DOctober 11, 2005RCastile Pellet Stove RR11Reference Materials7. Heat ExchangersThe heat exchangers transfer hot air from the exhaust
RRROctober 11,, 2005250-6422DPage 35Castile Pellet Stove 16. Snap Disc #1 (Convection Blower) 125°FSnap disc #1 is located on the right side of the
Page 36250-6422DOctober 11, 2005RCastile Pellet Stove RRB. Component LocationsHeat Exchanger TubesCleaning RodsTERMINAL BLOCKCENTER 2 SCREWS FORTHERM
RRROctober 11,, 2005250-6422DPage 37Castile Pellet Stove Figure 37.1 - Door, Face, Glass & Door Latch Assembly9810531112135214Figure 37.2 - Firep
Page 38250-6422DOctober 11, 2005RCastile Pellet Stove RRBeg. Manufacture Date: September, 2001Figure 38.13039493132333435363738404142434445464748505
RRROctober 11,, 2005250-6422DPage 39Castile Pellet Stove IMPORTANT: THIS IS DATED INFORMATION. The most current information is located o
Page 4250-6422DOctober 11, 2005RCastile Pellet Stove RR1Listing and Code ApprovalsA. Appliance CertificationC. Glass SpecificationsE. BTU & Effic
Page 40250-6422DOctober 11, 2005RCastile Pellet Stove RRItem NoService parts Part No.39 Snap Disc #1, 110 degree, Convection Fan 230-122039 Snap Disc
RRROctober 11,, 2005250-6422DPage 41Castile Pellet Stove Date of Service Performed By Description of ServiceE. SERVICE AND MAINTENANCE LOG
Page 42250-6422DOctober 11, 2005RCastile Pellet Stove RRDate of Service Performed By Description of ServiceE. SERVICE AND MAINTENANCE LOG (Cont’d))
RRROctober 11,, 2005250-6422DPage 43Castile Pellet Stove Lifetime WarrantyF. Warranty PolicyLIMITED LIFETIMEWARRANTYThe Hearth & Home Technologi
RHearth & Home Technologies1445 North HighwayColville, WA 99114Division of HNI INDUSTRIESwww.quadrafire.com250-6422D October 11, 2005Page 44CONTA
RRROctober 11,, 2005250-6422DPage 5Castile Pellet Stove 2Getting StartedA. Design, Installation & Location Considerations1. Appliance LocationCo
Page 6250-6422DOctober 11, 2005RCastile Pellet Stove RRE. Inspect Appliance & Components and Pre-Use Check ListReciprocating SawChannel LocksHamm
RRROctober 11,, 2005250-6422DPage 7Castile Pellet Stove 3Dimensions and ClearancesA. Appliance DimensionsFigure 7.2- Front ViewFigure 7.1 - Top Vie
Page 8250-6422DOctober 11, 2005RCastile Pellet Stove RRStraight Back Against WallInches MillimetersABack Wall to Appliance 2 51BSide Wall to Applian
RRROctober 11,, 2005250-6422DPage 9Castile Pellet Stove *L Exception for Horizontal Installations:USA INSTALLATIONS: A noncombustible floor protection
Commentaires sur ces manuels